This paper reports the design, construction, and operation of NWPU20 Micro Air Vehicle (MAV), which is the smallest that has, up to now, been developed in PR China. The miniaturization level in PR China makes smaller MAV, in our opinion, not possible to implement. The NWPU20 is a 20-centimeter span, battery powered, fixed-wing aircraft with an off-the-shelf color video camera that can transmit live video back to the ground station. The on-board electronic subsystems are smallest and lightest among the commercial products, including an 8-gram wireless video camera, an 8-gram receiver, a 5-gram electronic speed controller (ESC), two 4.5-gram fully proportional radio frequency control servos, and the total mass of NWPU20 is less than 80 grams. An experimental model was fabricated and tested in the Low Turbulent Flow Wind Tunnel (LTFWT) at Northwestern Polytechnical University (NWPU) to research low Reynolds number flow characteristics of the NWPU20. The result of the wind tunnel test shows that stall angle of attack of NWPU20 can reach 30°, which is higher than that of the general aircrafts, and the maximum lift-to-drag ratio of NWPU20 can nearly reach 6 at the angle of attack of 10°, which can satisfy design requirements of the NWPU20. A small-sized propulsion/torque testing system was developed to measure and analyze the propulsion and torque performances of the motor-propeller combination used in the NWPU20. A center of gravity (c.g.) testing apparatus was developed and used to adjust the c.g. of the NWPU20 so that it has good longitudinal static stability and control. The NWPU20 prototype has undergone successfully flight tests many times; it flies at 32 kilometers per hour, with an endurance of 15 minutes, and a maximum communications range of 300 meters. With the color video camera, NWPU20 successfully transmits real-time video back to the ground station. The success of NWPU20 proves preliminarily that 20-centimeter span micro air vehicle is feasible and usable.