【摘 要】
：
The driving voltage and current signals of piezoeeramie transducer (PZT) were measured directly by designing circuits from ultrasonic generator and using a data
【机 构】
：
School of Mechanical and Electronical Engineering,Key Laboratory of Modem Complex Equipment Design a
论文部分内容阅读
The driving voltage and current signals of piezoeeramie transducer (PZT) were measured directly by designing circuits from ultrasonic generator and using a data acquisition software system. The input impedance and power of PZT were investigated by using root mean square (RMS) calculation. The vibration driven by high frequency was tested by laser Doppler vibrometer (PSV-400-M2). And the thermosonic bonding features were observed by scanning electron microscope (JSM-6360LV). The results show that the input power of bonding is lower than that of no load. The input impedance of bonding is greater than that of no load.Nonlinear phase, plastic flow and expansion period, and strengthening bonding process are shown in the impedance and power curves. The ultrasonic power is in direct proportion to the vibration displacement driven by the power, and greater displacements driven by high power (5W) result in welding failure phenomena, such as crack, break, and peeling off in wedge bonding. For thermosonic flip chip bonding, the high power decreases position precision of bonding or results in slippage and rotation phenomena of bumps. To improve reliability and precision of thermosonic bonding, the low ultrasonic power (about 1-5W) should be chosen.
其他文献
通过实施国家测土配方施肥项目,开展了莎车县耕地土壤养分现状调查与分析。分析结果表明莎车县土壤有机质平均含量12.77g/kg、全氮0.73g/kg、碱解氮63.4mg/kg、有效磷9.5mg/k
研究了杭州市50个代表性居民小区土壤重金属(Cd、Cr、Cu、Ni、Pb和Zn)的含量,按照国家《土壤环境质量标准》对该市居民区土壤重金属污染状况做出了评价,并在GIS技术支持下,研究了土壤重金属污染的空间变异性。结果表明,杭州市居民区土壤均受到了不同程度的污染。其中4%的土壤轻度污染,54%的土壤中度污染,42%的土壤严重污染。土壤重金属污染具有显著的空间分异特征,严重污染区域大致呈西北-东南走
采用溶胶-凝胶法制备了负载于玻璃的CdO-TiO2复合光催化剂,并将其用于光催化降解染料酸性媒介红B.实验表明,n(Cd)/n(Ti)=0.04,涂覆5层,550℃煅烧0.5h的CdO-TiO2复合光催化剂
Based on the rough set theory which is a powerful tool in dealing with vagueness and uncertainty, an algorithm to mine association rules in incomplete informati
The hot deformation behaviors of GCr15 bearing steel were investigated by isothermal compression tests, performed on a Gleeble-3800 thermal-mechanical simulator
Zirconia powders doped with yttrium prepared by special liquid-phase precipitation method were sintered by spark plasma sintering (SPS) to obtain high performan
The annealing condition,Al content,and field amplitude dependences of the complex permeability for Nb-poor Finemet type alloys,Fe73.5Si13.5B9Cu1Nb3-xAlx (x=0,0.
To investigate the influence of stress alone on the stray field signals of ferromagnetic materials, the static tensile tests of 0.45%C steel and 45CrNiMoVA stee
A kind of networked control system is studied; the networked control system with noise disturbance is modeled based on information scheduling and control co-des
Fe/Gd multilayers were prepared by alternate vapor deposition of pure Fe and Gd at a rate of 0.01-0.03 nm/s in an ultra-high-vacuum electron-gun evaporation sys